De La Villa Mexican Restaurant receives C in Henry County health inspection

1. 01

   Employee health reporting

   Item 2-2A ↗

   PIC was unable to provide documentation or otherwise satisfactorily demonstrate during the inspection, that all food employees and conditional employees are informed of their responsibility to report to management information about their health and activities as it relates to diseases that are transmissible through food. PIC was provided with am Employee Illness Reporting document.

   Inspector’s full note +

   Code 511-6-1.03(2)(o)

   PIC was unable to provide documentation or otherwise satisfactorily demonstrate during the inspection, that all food employees and conditional employees are informed of their responsibility to report to management information about their health and activities as it relates to diseases that are transmissible through food. PIC was provided with am Employee Illness Reporting document. 511-6-1.03(2)(o) - Person-in-Charge Duties (Pf) Food employees and conditional employees are informed in a verifiable manner of their responsibility to report in accordance with the Chapter, to the person in charge, information about their health and activities as they relate to diseases that are transmissible through food; Pf and Corrected On-Site. New Violation.

   Official report · Item 2-2A ↗
   Corrected on siteNew violation
2. 02

   Food protection

   Item 4-2A ↗

   Observed food items in reach-in cooler and in container on shelf above steam table uncovered and not properly protected from contamination. 511-6-1.04(4)(c)1(iv) - Packaged & Unpackaged Food, food stored covered(C) (iv) Except as specified under paragraph 2. of this subsection and when cooling as specified in DPH Rule 511-6-1-.04(6)(e)2.(ii), storing the food in packages, covered containers, or wrappings, except for loosely covered or uncovered containers in which food is being cooled if protected from overhead contamination; New Violation.

   Inspector’s full note +

   Code 511-6-1.04(4)(c)1(iv)

   Observed food items in reach-in cooler and in container on shelf above steam table uncovered and not properly protected from contamination. 511-6-1.04(4)(c)1(iv) - Packaged & Unpackaged Food, food stored covered(C) (iv) Except as specified under paragraph 2. of this subsection and when cooling as specified in DPH Rule 511-6-1-.04(6)(e)2.(ii), storing the food in packages, covered containers, or wrappings, except for loosely covered or uncovered containers in which food is being cooled if protected from overhead contamination; New Violation.

   Official report · Item 4-2A ↗
   New violation
3. 03

   Food-contact surface sanitation

   Item 4-2B ↗

   Observed rust accumulation on interior of ice machine and dirty plate stored on RIC adjacent to prep top cooler. Employee removed item and placed it to be properly washed and sanitized.

   Inspector’s full note +

   Code 511-6-1.05(7)(b)

   Observed rust accumulation on interior of ice machine and dirty plate stored on RIC adjacent to prep top cooler. Employee removed item and placed it to be properly washed and sanitized. Violation Code Reference 511-6-1.05(7)(a)1 - Equipment, Food-Contact Surfaces,& Utensils (Pf) (7) Cleaning of Equipment and Utensils. (a) Equipment, Food-Contact Surfaces, and Utensils. 1. Equipment food-contact surfaces and utensils shall be clean to sight and touch. Pf. Corrected On-Site. New Violation.

   Official report · Item 4-2B ↗
   Corrected on siteNew violation
4. 04

   Food-contact surface sanitation

   Item 4-2B ↗

   Observed employee utilizing dish machine with chlorine sanitizer concentration at 0 ppm. Employee placed items to be properly cleaned and sanitized.

   Inspector’s full note +

   Code 511-6-1.05(6)(n)

   Observed employee utilizing dish machine with chlorine sanitizer concentration at 0 ppm. Employee placed items to be properly cleaned and sanitized. 511-6-1.05(6)(n) - Manual and Mechanical Warewashing Equipment, Chemical Sanitization-Temperature, pH, Concentration, Hardness (P,Pf) (n) Manual and Mechanical Warewashing Equipment, Chemical Sanitization - Temperature, pH, Concentration, and Hardness. A chemical sanitizer used in a sanitizing solution for a manual or mechanical operation at contact times specified under subsection (8)(b)3 of this Rule shall meet the requirements specified in DPH Rule 511-6-1-.07(6)(g), shall be used in accordance with the Environmental Protection Agency (EPA)-registered label use instructions P, and shall be used as follows: 1. A chlorine solution shall have a minimum temperature based on the concentration and pH of the solution as listed in the following chart; P Concentration Range Minimum Temperature MG/L PH 10 or less oF (oC) PH 8 or less oF (oC) 25-49 120 (49) 120 (49) 50-99 100 (38) 75 (24) 100 55 (13) 55 (13) 2. An iodine solution shall have a minimum temperature of 68°F (20°C)P minimum concentration between 12.5 ppm and 25 ppm, P and pH of 5.0 or less or a pH no higher than the level for which the manufacturer specifies for the solution to be effective; P 3. A quaternary ammonium compound solution shall have a minimum temperature of 75ºF (24ºC), P have a concentration as specified in DPH Rule 511-6-1-.07(6)(g) and as indicated by the manufacturer’s use directions included in the labeling, P and be used only in water with 500 ppm hardness or less or in water having a hardness no greater than specified by the EPA-registered label use instructions; P 4. If another solution of a chemical specified under paragraphs 1 through 3 of this subsection is used, the permit holder shall demonstrate to the Health Authority that the solution achieves sanitization and the use of the solution shall be approved; P 5. If a chemical sanitizer other than chlorine, iodine, or a quaternary ammonium compound is used, it shall be applied in accordance with the EPA-registered label use instructions ;P and 6. If a chemical sanitizer is generated by a device located on-site at the food service establishment, it shall be used as specified in 1-5 of this subsection and shall be produced by a device that: (i) complies with law as specified in sections 2(q)(1) and 12 of the Federal Insecticide, Fungicide, and Rodenticide Act (FIFRA), P (ii) complies with 40 CFR 152.500 Requirement for Devices and 40 CFR 156.10 Labeling Requirements, P (iii) displays the EPA device manufacturing facility registration number on the device, Pf and (iv) is operated and maintained in accordance with manufacturer’s instructions. Pf. 7. On-site chemical sanitizer generating equipment with active ingredients, such as copper, must be registered as pesticides. The active ingredient may be part of the equipment or separately added. Corrected On-Site. New Violation.

   Official report · Item 4-2B ↗
   Corrected on siteNew violation
5. 05

   Cold holding

   Item 6-1A ↗

   Observed multiple TCS items within the walk-in cooler above 41F. Employee began the process of discarding out of temperature food items.

   Inspector’s full note +

   Code 511-6-1.04(6)(f)

   Observed multiple TCS items within the walk-in cooler above 41F. Employee began the process of discarding out of temperature food items. 511-6-1.04(6)(f) - Time/Temperature Control for Safety; Cold Holding (P) (f) Time/Temperature Control for Safety Food, Hot and Cold Holding. Except during preparation, cooking, or cooling, or when time is used as the public health control, time/temperature control for safety food shall be maintained at 41°F (5°C) or below or 135°F (57°C) or above, except that roasts cooked to a temperature and for a time specified in subsection (5)(a)2 of this Rule and reheated using the same temperature and time conditions as cooking may be held at a temperature of 130°F (54°C) or above. P Corrected On-Site. New Violation.

   Official report · Item 6-1A ↗
   Corrected on siteNew violation
6. 06

   Wiping cloth use and storage

   Item 12C ↗

   Observed wet wiping cloths stored in a chlorine sanitizer solution at 10 ppm. Employee remade sanitizer solution.

   Inspector’s full note +

   Code 511-6-1.04(4)(m)

   Observed wet wiping cloths stored in a chlorine sanitizer solution at 10 ppm. Employee remade sanitizer solution. 511-6-1.04(4)(m) - Wiping Cloths, Use Limitation (C) (m) Wiping Cloths, Use Limitation. 1. Cloths in-use for wiping food spills from tableware and carry-out containers that occur as food is being served shall be: (i) Maintained dry; and (ii) Used for no other purpose. 2. Cloths in-use for wiping counters and other equipment surfaces shall be: (i) Held between uses in a chemical sanitizer solution at a concentration specified under DPH Rule 511-6-1-.05(6)(n); and (ii) Laundered daily. 3. Cloths in-use for wiping surfaces in contact with raw animal foods shall be kept separate from cloths used for other purposes. 4. Dry wiping cloths and the chemical sanitizing solutions in which wet wiping cloths are held between uses shall be free of food debris and visible soil. 5. Containers of chemical sanitizing solutions in which wet wiping cloths are held between uses shall be stored off the floor and used in a manner that prevents contamination of food, equipment, utensils, linens, single-service, or single-use articles. 6. Single-use disposable sanitizer wipes shall be used in accordance with EPA-approved manufacturer’s label use instructions. Repeat Violation.

   Official report · Item 12C ↗
   Repeat violation
7. 07

   Garbage disposal

   Item 17B ↗

   Observed trash accumulation around outside dumpster. 511-6-1.06(5)(o),(p) - Using Drain Plugs; Maintaining Refuse Areas (C) (o) Using Drain Plugs.

   Inspector’s full note +

   Code 511-6-1.06(5)(o),(p)

   Observed trash accumulation around outside dumpster. 511-6-1.06(5)(o),(p) - Using Drain Plugs; Maintaining Refuse Areas (C) (o) Using Drain Plugs. Drains in receptacles and waste handling units for refuse, recyclables, and returnables shall have drain plugs in place. (p) Maintaining Refuse Areas and Enclosures. A storage area and enclosure for refuse, recyclables, or returnables shall be maintained free of unnecessary items and clean. New Violation.

   Official report · Item 17B ↗
   New violation

Correction and repeat labels quote the report. An absent label leaves correction status unknown; a deadline does not confirm a correction.